Contact

larryf@happy-wanderers.com

Follow

Info

Information on this website is our opinion only. This site was created to help others considering this wonderful lifestyle, and for our own use.

Although we haven't stayed in many RV parks, most of those that we have stayed in had very low AC voltage. One park was down to 98 volts, which will cause damage to the Air Conditioner and Microwave if ran at this low voltage. Due to problems encountered, we purchased a portable 50 amp Autoformer by Hughes. When the RV park power drops below 117 volts, this electrical device boosts the voltage up to 10%. It does this by lowering the amps. Once the RV park power returns to 118 volts, the Autoformer just lets the power pass through without any boosting. The built in grounding continuity test offers protection against damage from open ground, open neutral or reverse polarity. All considered, this device protects the RV electrical system from brown-out damage.

Normally, your RV power cord plugs into the Autoformer, and the Autoformer plugs into the park power. The Autoformer has a handle to chain it to the RV park power pole. Besides worrying about a $400+ device being stolen, who wants to lug it back and forth every time we hooked up. Some people have hard-wired their Autoformer into their RV, but this makes the installation more permanent. In case of problems, or if I sold the RV, I still wanted the Autoformer to be transportable. My answer was to make it portable, but located inside of the RV instead of at the power pole. This simply involved:

  • Removing the RV's 30 ' 50 amp cord from the RV and replacing a female plug on one end. A male plug is already on the other end. An alternative would be to remove this cord and just buy a 30' 50 amp extension cord. But at $150+, I decided to modify the existing cord. If your rig is like mine and has 50 amp service, be sure to ONLY use a NEMA rated 14-50P (plug) and plug into a 14-50R (receptacle). If your RV is only 30 amp, use standard (ANSI C73.13) or NEMA TT-30P (plug) / TT-30R (receptacle).

    50amp Plug The cords Internal Installation

  • Installing a short, 2' (or 3') cord with a male plug at the same location you just removed the 30' cord. This is where power goes IN to the power breaker box.

The parts used are NOT CHEAP. One plug may cost around $40! Luckily, besides the Autoformer, there were only three parts I needed to purchase. 1) The Female 14-50R (I found an affordable one at Home Depot for $15), 2) the Male 14-50P (I had to go to an electrical supply store for this - $$$), and 3) a couple feet of the flexible, 4-wire cable. I asked for 50 amp cable for a manufactured home. Besides the Autoformer, my total cost was around $50.

As this picture shows, the Autoformer fit in nicely in my electrical The complete installationcompartment. You can see the Autoformer tucked away in the back, with the 30' RV cable plugged into the generator. You can't see the other end of this 30' cable, which is plugged into a short cable with a female receptacle which comes attached to the Autoformer. You can also see the new, short cable plugged into the Autoformer, which is going onto the RV breaker box. This places the Autoformer in the path from the power source (park or generator) to the RV.

 

<Bypassing the AutoformerThis picture shows the Autoformer being bypassed. If needed, I could remove the Autoformer completely from the RV now. You also see the short input cable plugged into the female receptacle of the 30' cable. The other end of the 30' cable would be plugged into the RV park power, or the generator (I don't have an automatic power switch - I manually move the cable as needed).

 

Latest Blogs

18 May 2025
Travel
2025 Travel Logs
North America Travel
A couple weeks ago, we made a 4-day trip to Navajo country in Southwest Utah, visiting Monument Valley. We took the RV out and traveled with neighbors Randy and Patty and Steve and Debbie. This trip was actually Debbie and Steve's idea. It's a p...
25 April 2025
General Info
I revised the design of our Pegs & Jokers game set. While the game is the same, the playing pieces are slightly smaller and connect together in a different manner. This makes the game pieces fit better in the provided carrying bag and prevents ac...
15 April 2025
Travel
2025 Travel Logs
After leaving El Fuerte's heat and bugs we were happy to be on a beach for the next 5 days. We had a relatively short driving day with a grocery stop at Walmart before stopping for our stay at Mr. Moro Hotel and RV Park in Las Glorias Sinaloa. The ne...
19 March 2025
Travel
2025 Travel Logs
While the name of our next RV caravan tour is called "Copper Canyon", it will be a highlight. Our main destination and turnaround point will be Mazatlán. After we crossed back into the U.S. at the east Mexicali border from our Baja trip, we made a lo...
27 February 2025
Travel
2025 Travel Logs
While staying in La Paz, we had a bus trip to Todos Santos and stopped at a cafe on the way. Good drinks and food, then we continued on the trip. After a short tour of the town and spending a couple hours exploring, we headed off to have lunch at "Th...